Tech Tip: Hyundai MIL On with DTCs Set and Fail Safe Mode, Harsh Engagement – UnderhoodService

Tech Tip: Hyundai MIL On with DTCs Set and Fail Safe Mode, Harsh Engagement

An improperly functioning input speed sensor or output speed sensor may result in the following conditions: Check Engine light on; Harsh P-R or P-D engagement shock; Transaxle in third gear fail-safe; and/or Diagnostic trouble codes.

Models affected:

1999 Sonata

2001 Elantra, Santa Fe and XG

2003 Tiburon

2005 Tucson

2006 Azera

2007 Entourage

fig. 1

Automatic transaxle DTCs: P0715, P0716, P0717, P0720, P0721 and P0722

An improperly functioning input speed sensor or output speed sensor (see Fig. 1) may result in the following conditions:

• Check Engine light on;

• Harsh P-R or P-D engagement shock;

• Transaxle in third gear fail-safe; and/or

• Diagnostic trouble codes.

 

Parts Information:

Input speed sensor: 42620-39051 or 42620-39200

Output speed sensor: 42621-39052 or 42621-39200

 

Service Procedure:

1. Using a GDS, check for DTCs in both the “Engine” and “Automatic Transaxle” menus. Record the DTC(s) and description.

2. From the GDS, select:

Vehicle > “Auto Transaxle” menu > “Current Data” > “Input speed sensor” and “Output speed sensor.” Drive the vehicle and monitor the input and output speed sensors. If the sensors show:

– Continuous output, the wiring currently has no open/shorts. Go to Step 6.

– No output, go to Step 3.

3. Check the wiring harness visually for an open circuit or short circuit to ground. Check for a pinched harness at the PCM/TCM attachment bolts.fig. 2

4. Disconnect the connectors at the input and output speed sensor and PCM/TCM. Check for bent pins or pins not fully inserted into the connector.

5. If a harness open/short is found, repair or replace the ECM control harness between the PCM/TCM and transaxle and go to Step 8. If not, go to Step 6.Fig. 3

6. P0722 only: For 2006 and later Sonata and Azera, 2007 and later Santa Fe and Entourage vehicles, check the ground bolt at the location shown in Fig. 2 below and Fig. 3. Confirm the threads are clean and the bolt is tight.

7. If the ground bolts are clean and tight, follow the repair procedures shown in Chart 1.

8. Drive the vehicle for two key-on to key-off driving cycles. If the codes:

– Do not set again, return the vehicle to the ­customer.

– Set again, go to step 8.

Chart 1
DTC       Description                    Repair Procedure
P0715    Input speed sensor         Replace input speed sensor
               – no signal       
P0716    Input speed sensor
               – range/performance
P0717    Input speed sensor
               – no signal

P0720    Output speed sensor circuit    Replace output speed sensor              
P0721    Output speed sensor
               – open/short
P0722    Output speed sensor
               – no signal

P0700,    TCM MIL request to ECM    Erase code
P1529
 

9. Exchange a PCM or TCM from a similar year and model vehicle (excluding vehicles with an immobilizer). If the codes:

– Set again, replace the control wiring harness.

– Do not set again, replace the PCM or TCM.

Courtesy of Mitchell 1.

You May Also Like

Belts and Pulley Alignment

A misalignment of the plane of the belt can occur when a pulley is not parallel to the other pulleys on the belt drive system.

Drive Belt Alignment Alignment is key to the health of an engine belt. The belt drive system is designed to create friction between the grooves on the belt and pulley to transfer power from the crankshaft to the alternator, water pump or power steering pump. If the grooves on the belt do not align with the pulleys, the friction won’t be evenly applied and can result in wear and noise.

Diagnosing Misfires

What if there are no codes and a misfire is intermittent? This is where it gets complicated.

Lifter Deactivation

The area of contact between the lifters and cam lobes is the highest loaded surface inside an engine.

Alternator Testing For No Charge Conditions

Many alternator problems turn out to be nothing more than a bad connection at the alternator or a bad wiring harness.

Understanding Coolants

All-season coolant used inorganic acid technology and worked great for almost 30 years.

Other Posts

Hybrid Vehicle Fluid Maintenance

There are opportunities your shop can’t pass up just because the car or SUV has a hybrid badge on the back.

Ignition Coil Output

To see inductance inside the primary windings, use an amp probe placed around the positive wire for the ignition coil.

Using a Scope

Ignition coil and plug diagnostics.

Scope-diagnostics
Repairing Wiring Harnesses

A guide to probing and poking.