Tech Tip: Dodge Hard or No Start During Cool Weather – UnderhoodService

Main Navigation

Advertisement
Social Connect
Resources
Our Brand Family
UnderhoodService
Technical resources to help diagnose and repair engine-related service issues.
Post

Tech Tip: Dodge Hard or No Start During Cool Weather

A hard or no start condition during cool weather, with hard fault code 22 in memory (non-magnum engines), may be caused by defective coolant temperature sensor (CTS) wiring connections.

Underhood Service Staff Writers
By Underhood Service Staff Writers

Models affected:
• 1988-’93 Caravan 2.5L, 3.0L; and
• 1990-’93 Caravan 3.3L.

Related Articles

Symptom: Hard or no start during cool weather, with hard fault code 22 in memory (non-magnum engines).

Problem: Defective coolant temperature sensor (CTS) wiring connections.

Test & Fix: The CTS sensor resistance should be 7,000-13,000 ohms at 70° F. If it isn’t, replace the sensor. If the sensor values are OK, proceed with the wiring repair by installing a new pigtail connector #4414901 and heat-shrink tubing #4419644.

Courtesy of IDENTIFIX.

For additional tech tips, visit www.identifix.com.

You May Also Like

Engine Compartment

Inspection Tips For Chain-Driven Water Pumps

If one water pump fails sooner and is replaced without an investigation, the new pump is likely doomed.

Andrew Markel
By Andrew Markel
Water pump feature

Automakers are always trying to remove items from the accessory drive belt. This improves the efficiency of the engine and can extend the life of the belt. But where do you put the water pump? Some manufacturers like Ford and Mazda have driven the pumps with a pulley on the exhaust camshaft. Other manufacturers have decided that the chain on the front of the engine may be a better solution.

Read Full Article

More Posts
Throttle-By-Wire Diagnostics

Throttle-by-wire systems proactively manage the air and fuel going into the combustion chamber.

By Andrew Markel
Hyundai & Kia Hybrid Drivetrain

The Hyundai hybrid system has a motor control unit (MCU) and hybrid control unit (HCU).

By Andrew Markel
Flash, Qmerit Partner to Advance EV Charging in the U.S.

Qmerit’s maintenance network will provide Flash with a single source for maintenance across its charging locations.

By Underhood Service Staff Writers
Acura Turbo Engine Service

It is important to check the operation of the solenoids that control vacuum to the actuators.

By Andrew Markel

Other Posts

Why Do Timing Chains Stretch?

As the timing chain wears, it can change the timing of the camshaft and crankshaft.

By Andrew Markel
Subaru EJ25 Head Gasket Problems

Most of the EJ head gasket failures occur around the 100,000-mile mark and start as a slow oil or coolant leak.

By Andrew Markel
Report: U.S. EV Investments Rapidly Increasing

Electric vehicle and battery manufacturing grew by a reported $92.3 billion over the past 12 months.

By Underhood Service Staff Writers
Different Nameplates, Different Expectations

One thing Asian nameplates share is that the system voltage must stay in a specific range during the reflashing procedure.

By Andrew Markel