Toyota Tech Tip: Rough Idle, Surging Between 500 To 800 RPM – UnderhoodService

Toyota Tech Tip: Rough Idle, Surging Between 500 To 800 RPM

The owner of 2005 Toyota Avalon complains check engine light is on, rough idle and engine idle surging between 500 and 800 rpm. The technician retrieved Diagnostic Trouble Code (DTC) P0171 and P0174 (System too lean banks 1 and 2). The technician replaced the air fuel sensors on both banks and cleared DTCs. After driving vehicle for approximately one mile, all symptoms returned.

Model: 2005 Toyota Avalon and some models with similar system configurations, such as 2006 Camry models
 
Condition: Client complains check engine light is on, rough idle and engine idle surging between 500 and 800 rpm. Technician retrieved Diagnostic Trouble Code (DTC) P0171 and P0174 (System too lean banks 1 and 2). Technician replaced the air fuel sensors on both banks and cleared DTCs. After driving vehicle for approximately one mile, all symptoms returned.
 
Correction: Replace cracked hose; erase DTCs and road test.
 
Explanation: A vacuum leak caused by a cracked hose between the charcoal canister purge valve and intake manifold will cause the air fuel sensor to detect a high amount of oxygen in the exhaust system, producing a positive current flow and increasing the voltage signal above 3.3 volts. The engine control unit (ECU) on this Toyota puts out a voltage signal relatively proportional to exhaust oxygen content, detecting the change and strength of current flow. 
 
At 3.3 volts, the air fuel ratio is 14.7 to 1 (stoichiometric) and there is no current flow. The ECU is receiving a false signal because the air leak is in the intake system behind the air mass meter. This causes the ECU to change injector opening duration rapidly as it analyzes the conflicting signals. OBD II is designed to monitor fuel trim on a continuous basis, thus causing the DTCs P0171 and P0174 to set. OBD II monitors evaporative emissions by checking for fuel vapor leaks once a drive cycle. If it detects no air flow when the charcoal canister purge valve is opened, DTC P0441 will set on a second drive cycle.
 
Courtesy of DENSO

You May Also Like

10 Commandments Of Catalytic Converter Replacement

Paperwork, laws and warranty issues can cause headaches.

Catalytic converter replacement can be one of the most arduous repairs a shop takes on. It is not that the repair itself is overly complicated; it is the paperwork, laws and warranty issues that can be the real headache. Below are the 10 commandments of a catalytic converter replacement handed down from the EPA.

Tech Tip: No Start in Cold Weather Due to No Weep Hole

This condition can be caused by condensation freezing in the muffler assembly.

Determining Catalytic Converter Efficiency

Almost every part on the engine determines how long a catalytic converter will last.

Talking To Customers About Oxygen Sensors

One of the toughest components to sell as a maintenance item, or even a replacement item, is an oxygen sensor.

PCV System DTC

PCV systems are far more complex now, but they are also much better at controlling crankcase pressure.

Other Posts

Why Alternators Are Subject To Ripple Voltage

The alternator produces an AC current that must be converted into DC current by way of a rectifier.

Belts and Pulley Alignment

A misalignment of the plane of the belt can occur when a pulley is not parallel to the other pulleys on the belt drive system.

Diagnosing Misfires

What if there are no codes and a misfire is intermittent? This is where it gets complicated.

Lifter Deactivation

The area of contact between the lifters and cam lobes is the highest loaded surface inside an engine.