TECH TIP: Using a Five-Gas Analyzer to Diagnose Catalytic Converters – UnderhoodService

TECH TIP: Using a Five-Gas Analyzer to Diagnose Catalytic Converters

One of the most effective ways to resolve emissions issues is by sampling the exhaust gases with a five-gas analyzer. Levels of the five gases can indicate the root cause of the problem.
One of the most effective ways to resolve emissions issues is by sampling the exhaust gases with a five-gas analyzer. Levels of the five gases can indicate the root cause of the problem:
• High HC emissions indicate unburned fuel.
• High CO levels indicate partially burnt fuel or oil.
• High NOx levels are normally caused by high combustion temperatures and pressures, slightly lean AFR and excessively advanced ignition timing.
• Tailpipe emissions readings low in HC and CO levels with high NOx emissions are typically NOT caused by a defective converter. The low HC and CO readings indicate that the converter is functioning. The root cause of the problem is an engine which is emitting excessively high NOx emissions. These high NOx emissions may reduce the durability and efficiency of the converter.

 
 

You May Also Like

How To Diagnose Slow or Sluggish Oxygen Sensors

When oxygen sensors are tested, manufacturers will introduce small amounts of oil to measure sensitivity.

An engine management system is always trying to find the perfect air/fuel ratio. But it is next to impossible to walk the line between too rich or too lean. With every revolution of the crankshaft, small changes in the air, fuel and operating conditions can cause changes to the oxygen content coming out of the exhaust port.

E-15 Ethanol Damage to Fuel Pumps

One of the problems with ethanol is how it reacts to water in the air and in the tank.

Oxygen Sensor Questions Answered

If an O2 sensor is not reading properly or is borderline, it should be replaced regardless of its age or mileage.

Managing (DPF) Diesel Particulate Filter Regeneration Cycles

The DPF is designed to store the soot and ash, to later burn them off during a regeneration cycle.

Ultimate Underhood – Gasoline Particulate Filters

Just like a DPF, a gasoline particulate filter (GPF) traps and stores soot particles in the exhaust stream.

Other Posts
How-to Complete Emissions Monitors Faster

This video will focus on how a product like CAT COMPLETE can improve the chances of completing the monitors faster. This video is sponsored by Rislone.

U.S. House Schedules Vote to Stop EPA Emissions Mandate

The bill would prohibit the EPA from finalizing federal emissions standards for light- and medium-duty vehicles model years ’27 to ’32.

Forecast: 80% Drop In U.S. Transportation Emissions By 2050

NREL says rapid adoption of zero-emission vehicles is critical to reduce emissions.

Understanding Emissions

Modern EVAP systems are selective with how they vent vapors back into the engine. Sponsored by Standard.