Tech Tip: Getting Your (Piston) Groove Back – UnderhoodService

Tech Tip: Getting Your (Piston) Groove Back

The piston ring set and the piston must be engineered to complement each other from a standpoint of clearance between the back of the piston ring and the bottom of the piston groove. This clearance is referred to as back clearance. If the clearance is not sufficient, severe engine damage can result when the piston and rings are installed in the engine.

Getting Your Groove Back
The piston ring set and the piston must be engineered to complement each other from a standpoint of clearance between the back of the piston ring and the bottom of the piston groove. figure 1

This clearance is referred to as back clearance. If the clearance is not sufficient, severe engine damage can result when the piston and rings are installed in the engine.

Figure 1 illustrates groove depths of a piston.


Checking for Piston Ring Groove Back Clearance
It’s simple to check compression ring back clearance. Place the outer diameter (O.D.) of the piston ring fully into the piston groove as illustrated in Figure 2.

No portion of the inside diameter (I.D.) should protrude beyond the piston land.

Figure 2Oil rings, however, are more difficult to check. By placing the oil rails and expander together as they would be assembled and inserting as shown, it can determine if back clearance exists. Minimum clearance should be 0.015”.


Pistons are designed to have considerable more clearance in the ring land area than in the skirt area. Be sure the ring or ring assembly does not protrude beyond the groove lands.

The design in head clearance will ensure sufficient clearance behind the ring when the piston is installed in the cylinder.


In situations where piston grooves are deeper, the oil ring can be difficult to install because the oil ring assembly tends to “pop off” the piston.

Once the rings are installed, however, they will perform properly even though there is more than normal back clearance.

Some engine manufacturers have changed piston dimensions within an engine model making it necessary to catalog two piston ring sets — deep groove and shallow groove — within one engine model.

Source: Hastings Piston Rings.

You May Also Like

Alternator Testing For No Charge Conditions

Many alternator problems turn out to be nothing more than a bad connection at the alternator or a bad wiring harness.

If only battery voltage is present at the battery on a running engine, does this mean the alternator is “bad?” No, it does not. It only means that the alternator is not charging, but does not reveal why. Therefore, it does not point to a faulty alternator. All too often, the alternator is condemned by technicians due to this test alone. The cause could instead be a module that distributes the power to the vehicle and regulates the alternator.

Understanding Coolants

All-season coolant used inorganic acid technology and worked great for almost 30 years.

Ignition System Do’s and Don’ts

Why do ignition systems give technicians problems when diagnosing ignition-related misfires? The answer is that some technicians use tests that might give inconclusive results or do damage to the coil or drivers inside a module.

Tools To Service Serpentine Belts

Servicing the serpentine belt on some vehicles is a tough task.

Battery Charging and Diagnostics

Here are six tips to use when diagnosing a vehicle with a dead battery. 

Other Posts

Why Do Timing Chains Stretch?

As the timing chain wears, it can change the timing of the camshaft and crankshaft.

Carbon Deposits and Direct Injection Engines

The primary cause of these problems is that fuel and added detergents are not hitting the back of the intake valves.

Acura Turbo Engine Service

It is important to check the operation of the solenoids that control vacuum to the actuators.

Subaru EJ25 Head Gasket Problems

Most of the EJ head gasket failures occur around the 100,000-mile mark and start as a slow oil or coolant leak.