DTC P0116 Hyundai Cold Engine

Cold Engine Stumble/DTC P0116/MIL ON

Some 2000-2002 Hyundai Accents with 1.5L SOHC and 1.6L DOHC engines may experience the following symptoms in hot and humid weather:

  • Slower than usual acceleration after an initial cold start (engine is cold soaked).

  • Greater than usual rpm drop when engaging drive or reverse (on ATM-equipped vehicles) after an initial cold start.

    Some 2002 1.6L Accents may turn on the Check Engine light and store diagnostic trouble code P0116 (Engine Coolant Temperature Sensor Range/ Performance Problem) in the ECM. This code can be falsely set under certain driving conditions. Check the Engine Coolant Temperature (ECT) sensor to make sure that it’s functioning properly. When the engine is cold soaked, the ECT and intake air temperature should read approximately the same temperature. When the engine is fully warmed-up, the ECT should read about 190

    You May Also Like

    Tools To Service Serpentine Belts

    Servicing the serpentine belt on some vehicles is a tough task.

    Servicing the serpentine belt on some vehicles is a tough task. Without the right tools it is almost impossible. Here are six tools your shop needs to make your next belt replacement more productive.

    Don’t Fight It
    If you are still fighting belt tensioners with 3/8” breaker bar and wrenches, there are better solutions. There are serpentine belt kits that can help you get the right angle and attachment point on a tensioner to remove the old belt and install the new belt.

    Battery Charging and Diagnostics

    Here are six tips to use when diagnosing a vehicle with a dead battery. 

    Why Do Timing Chains Stretch?

    As the timing chain wears, it can change the timing of the camshaft and crankshaft.

    Carbon Deposits and Direct Injection Engines

    The primary cause of these problems is that fuel and added detergents are not hitting the back of the intake valves.

    Acura Turbo Engine Service

    It is important to check the operation of the solenoids that control vacuum to the actuators.

    Other Posts

    Subaru EJ25 Head Gasket Problems

    Most of the EJ head gasket failures occur around the 100,000-mile mark and start as a slow oil or coolant leak.

    Honda Electronic Throttle Body Service Tips

    Using care and following OEM procedures will help you to avoid unnecessary parts replacement and comebacks.

    New Oil Specifications

    Many 0W16 oils have a new donut certification mark on the bottle called API SN-PLUS and SN-PLUS Resource Conserving.

    Solving Intermittent Overheating

    New cooling systems anticipate and influence changes in coolant temperature.